Daily Care

From Datsun 1200 Technical
Jump to navigation Jump to search

<-- back to Owners manual


Daily Care is a section in the owners manual.





Introduction

1972 USA Owners manual (Page 21 ... 25):


  [[1972#29381|]]




Daily Care


Before driving or whenever you call at a gas-station, be sure to check the following items.


  1. Fuel tank
  1. Engine oil
  1. Battery
  1. Radiator coolant
  1. Tire pressure, wear and scars

Recommended tire pressure: See page 26.

  1. Directional indicators, horn and all lights and switches for proper operation.
  1. Windshield washer fluid level
  1. Leakage and amount of fluid in brake and clutch master cylinders
  1. Clutch and brake operation
  1. Steering wheel play


Album 29381


1974 B120 Owner's Manual (Page 19 ... 23)


http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_00%20cover.jpg   http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_19.jpg




DAILY CARE


Before driving or whenever you call at a gas-station, be sure to check the following items.


  1. Keep the gas tank filled.
  1. Check the engine oil.
  1. Check the battery.
  1. Check the radiator coolant.
  1. Check tire pressure, wear and scars.
  1. Check directional indicators, horn and all lights and switches for proper operation.
  1. Check the windshield washer fluid level.
  1. Check leakage and amount of fluid in brake and clutch master cylinders.
  1. Check clutch and brake operation.
  1. Check steering wheel play.


https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/18.jpg



Opening the Hood

See also: Hood


1972 USA Owners manual (Page 21 ... 21):


  [[1972#29381|]]




OPENING THE HOOD


Pull the hood lock handle located at the lower area of the instrument panel.


Release safety catch located under the center edge of the hood and raise the hood and set the hood stay.


Album 29381


1974 B120 Owner's Manual (Page 18 ... 18)


http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_00%20cover.jpg   http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_18.jpg




OPENING THE HOOD


Pull the hood lock handle located at the lower area of the instrument panel.


Release safety catch located under the center edge of the hood and raise the hood and set the hood stay.


HOOD LOCK


Be sure to check the hood closed firmly functioning hood lock mechanism. Lubricate hood lock assembly every 9,000 km (6,000 miles).


Coat grease to all functioning parts after wiping off any accumulation of dirt on lock parts. Make certain that the lock and release mechanisms operate smoothly several times.


https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/18.jpg



Fuel Recommendation

Main: Fuel Requirements


1972 USA Owners manual (Page 22 ... 22):


  [[1972#29382|]]




FUEL RECOMMENDATION


The A12, four cylinder, in line, five bearing crankshaft engine will give you top power and high level performance using gasoline above 91 octan [sic] under almost all driving conditions.


If "knocking" occurs with the gasoline you are using, It can be cured by slightly retarding the spark timing or other engine adjustments. If not, switch to a higher grade octane.


Album 29382


1974 B120 Owner's Manual (Page 19 ... 19)


http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_00%20cover.jpg   http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_19.jpg




FUEL RECOMMENDATION


Your DATSUN is designed to operate on a good quality of gasoline with a minimum octane rating of 88, which is rated by the research method.


Using a fuel with too low an octane rating will result in "spark knock". Continuous or excessive "spark knock" may result in engine damage.


If "spark knock" occurs, change to the next higher grade of fuel or consult your designated NISSAN/DATSUN dealer.


https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/19.jpg



Fuel Filler Lid

Main: Fuel Lid


1972 USA Owners manual (Page 22 ... 22):


  [[1972#29382|]]




FUEL FILLER LID


Album 29382



Selection of Right Lubricants

Main: Lubricants


1972 USA Owners manual (Page 22 ... 22):


  [[1972#29382|]]




SELECTION OF RIGHT LUBRICANT


The selection of the right lubricant and its correct application does much to increase the life and improve the operation of all the moving parts of the vehicle. The prescribed lubricating intervals in the "Periodical Maintenance and Lubrication Schedule" should be strictly followed, under normal conditions. Severe of [sic] unusual operating conditions are: stop and start city driving, driving in extreme cold or hot temperatures, driving in very dusty areas or in rough roads, driving in rainy day, constant high speed-driving, etc.


The recommended viscosity grade of lubricants of the engine, transmission and rear axle varies with temperature changes. The lubricants provided at the factory are intended for use at temperatures between 32 and 90°F (0 and 32°C).


In the cold season, a low viscosity oil gives better lubrication because it flows more easily. In the hot season, a high viscosity oil is used since oil tends to thin out with higher operating temperature.


Use of oil with SAE numbers shown in the "#Recommended SAE Viscosity Number."


Engine oil capacity


  • Oil pan: 2-7/8 U.S.qts., 2-3/8 Imper.qts. (2.7 ℓ)
  • Oil filter: 1-3/8 U.S.pints., 1 Imper.pint. (0.54 ℓ )


It is normal to add some engine oil between the 3,000 miles (5,000 km) oil changes. The amount added will vary with severity of operation.


Album 29382


1974 B120 Owner's Manual (Page 19 ... 19)


http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_00%20cover.jpg   http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_19.jpg




SELECTION OF RIGHT LUBRICANT


The selection of the proper lubricant and its correct application does much to increase the life and improve the operation of all the moving parts of the vehicle. The prescribed lubricating intervals in the "Periodical Maintenance and Lubrication Schedule" should be strictly followed, under normal conditions. Under severe of [sic] unusual operating conditions are: stop and start city driving, driving in extreme cold or hot temperatures, driving in very dusty areas or in rough roads, driving in rainy day, constant high speed-driving, etc.


The recommended viscosity grade of lubricants of the engine, transmission and rear axle varies as the temperature changes. The lubricants filled at the factory are for the condition of 0° to 32°C (32° to 90°F).


In cold season, a low viscosity oil gives better lubrication because it flows more easily. In hot season, a high viscosity oil is used since oil tends to thin out with higher operating temperature.


Use of oils with SAE numbers shown in the "#Recommended SAE Viscosity Number" is recommended.


Engine oil capacity


  • Oil pan: 2.7 liters (2-7/8 U.S.qt, 2-3/8 Imp.qt)
  • Oil filter: 0.54 liter (1-1/8 U.S.pt, 1 Imp.pt)


It is normal to add some engine oil between 3,000 km (2,000 miles) oil changes. The amount added will vary with severity of operation.


https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/19.jpg



Recommended Lubricants

Main: Lubricants


1972 USA Owners manual (Page 23 ... 23):


  [[1972#29383|]]




RECOMMENDED LUBRICANTS


Album 29383



https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/20.jpg



Recommended SAE Viscosity Number

Main: Engine Oil Specifications




Main: Gear Oil Viscosity


1972 USA Owners manual (Page 24 ... 24):


  [[1972#29384|]]




RECOMMENDED SAE VISCOSITY NUMBER


Album 30454

Ambient Temperature Range



Album 30453

Temperature Range Anticipated Before Next Oil Change



Battery

Main: Battery Maintenance


1972 USA Owners manual (Page 24 ... 24):


  [[1972#29384|]]




BATTERY


Check the electrolyte level in each battery cell about once a month. If necessary add distilled water to bring the level up approximately 5 mm (0.2 in) above the plates. Do not overfill.


To prevent corrosion and leakage of current keep the top of the battery clean and dry.


Also keep the terminals clean and well covered with petroleum jelly.


During freezing weather


When distilled water has been added, drive the car for a moment to make sure that the added water mixes thoroughly with the battery's electrolyte solution. Other


wise, the water may freeze and damage the battery.


Album 29384


1200 Pickup manual uses the word "vehicle" instead of "car"


1974 B120 Owner's Manual (Page 21 ... 21)


http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_00%20cover.jpg   http://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/th_21.jpg




BATTERY


Check the electrolyte level in each battery cell about once a month. If necessary add distilled water to bring the level up approximately 5 mm (0.2 in) above the plates. Do not overfill.


To prevent corrosion and leakage of current keep the top of the battery clean and dry.


Also keep the terminals clean and well covered with petroleum jelly.


During freezing weather


When distilled water has been added, drive the vehicle for a moment to make sure that the added water mixes thoroughly with the battery's electrolyte solution. Other


wise, the water may freeze and damage the battery.


https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/21.jpg



Cooling System

Main: Coolant


1972 USA Owners manual (Page 22 ... 22):


  [[1972#29385|]]




COOLING SYSTEM


Album 29385



https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/22.jpg



Windshield Washer Tank

Main: Kangaroo Bag


1972 USA Owners manual (Page 22 ... 22):


  [[1972#29385|]]




WINDSHIELD WASHER TANK


Album 29385



https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/22.jpg



Brake and Clutch Master Cylinders

Main: Brake Master Cylinder




Main: Clutch Master Cylinder (LHD only)


1972 USA Owners manual (Page 22 ... 22):


  [[1972#29385|]]




BRAKE AND CLUTCH MASTER CYLINDERS


Album 29385



https://i297.photobucket.com/albums/mm219/ddgonzal/Datsun%201200/owners_manual/1974/22.jpg 


¤

Retrieved from "https://datsun1200.tougetechnologies.com/index.php?title=Daily_Care&oldid=48997"